Stage 3 Para Neon Srt-4 De Mopar

INFORMATION SHEET

STAGE 3R TURBO UPGRADE KIT
2003-2004 DODGE SRT-4
PART NUMBER P5007864 (with Turbo Toys) P4510338 (without Turbo Toys) P4510339 (Stage 2 to Stage 3R Upgrade Kit)
Stage 3R Turbo Upgrade Kit Components • (1) Stage 3R PCM • (4) 682 cc/min Fuel Injectors* • (1) 3.0 bar MAP Sensor* • (1) 3.0 bar TIP Sensor* • (1) Block-off Connector for PCM • (1) Mopar TD05HR TurbochargerAssembly (with integrated exhaust manifold) and Penta-flange Exhaust Elbow • (1) Demand-regulated Fuel Rail Assembly • (1) 180 lph Fuel Pump Module • (1) Fuel Rail Regulator Hose Kit • (1) Exhaust Manifold Gasket • (1) Exhaust Flex Joint Gasket • (7) Exhaust Manifold Bolts • (6) Oil/Water Banjo Fitting Sealing Washers • (1) Oil Return Line Gasket • (1) Vacuum Harness Securing Kit * Not included in theStage 2 to Stage 3R Upgrade Kit (P4510339). Recommended Upgrades • P4510647 Performance Clutch • P4510548 Blow-off Valve Conversion Kit • W Speed-rated Tires • P4510461 Cat-Back Exhaust System • NGK #4306 Spark Plugs (or equivalent) • Spark Plug Gap of .035"–.040" Stage 3R Turbo Upgrade Kit Feature Description • Mopar TD05HR Turbocharger. The Stage 3R kit uses a TD05HR-15GK2-10cm2 turbo. Thecompressor and turbine are larger than the production turbo to produce higher power more efficiently. • Ti-Al Turbine Wheel. The Mopar TD05HR Turbocharger employs a low mass Titanium Aluminide (Ti-Al) turbine wheel that has less rotational inertia. Less inertia results in better turbocharger response. • Increased WOT and Part Throttle Boost. To develop the impressive peak power and peak torque for theStage 3R package, the boost pressures have been optimized for wide-open throttle (WOT) conditions. The boost was also recalibrated for part throttle conditions to enhance the drivability. • Boost Hold Feature During WOT Shifts. Keep the pedal to the metal, blip the clutch, and grab the next gear. Do it fast enough before the redline, and your reward will be a zero-lag, constant boost shift.K68587011 SRT-4 Engine Performance Chart
Vehicle Package Torque Rating SRT-4 Stage 3R 325 ft-lb @ 3200–4800 rpm SRT-4 Stage 3R 365 ft-lb @ 3200–4800 rpm High Octane Power Rating 310 hp @ 5600 rpm 355 hp @ 5200 rpm

• More Aggressive Exhaust Note During Deceleration. More of the Mopar signature pops, snaps, and burbles during closed throttle decelerations and between shifts. • Optimized Calibration forthe Mopar Performance Blow-Off Valve (sold separately). The Stage 3R kit has improved the functionality and the audible performance of the integrated recirculation valve with the BOV Conversion Kit in mind. • Increased Rev. Limit. The Stage 3R calibration increases the engine redline from 6240 RPM to 6500 RPM.

NOTE: ALL RATINGS ARE WITH CAT-BACK SYSTEM P4510461. Mopar Performance parts aresold “as is,” without any warranty whatsoever. Implied warranties, including warranties of merchantability or fitness for a particular purpose, are excluded. The entire risk as to quality and performance of such parts is with the buyer. Should such parts prove defective following their purchase, the buyer and not the manufacturer, distributor or retailer, assumes the entire cost of all necessaryservicing or repair. Chrysler, Dodge, and Jeep® vehicle and parts warranties are voided if the vehicle or parts are used for competition or if they fail as a result of modification. Page 1 of 2

10/01/04
©2004, DaimlerChrysler Motors Company, LLC. Mopar is a registered trademark of DaimlerChrysler Motors Cmpany, LLC. All rights reserved.

INFORMATION SHEET

STAGE 3R TURBO UPGRADE KIT2003-2004 DODGE SRT-4
PART NUMBER P5007864 (with Turbo Toys) P4510338 (without Turbo Toys) P4510339 (Stage 2 to Stage 3R Upgrade Kit)

SPECIAL NOTE: P0633 Fault Code Explanation It is normal for the Mopar Turbo Upgrade Kits to set the P0633 fault code. This code will not activate the MIL (Malfunction Indicator Light), but it will be displayed during a diagnostic check. The vehicle functionality or...