Tractor

INTERACTIVE SCHEMATIC
Bookmarks
Options
X

Features Cover Page Information
Component Table Tap Table Fluid Power Symbols Electrical Symbols

This document is best viewed at a screen resolution of 1024 X 768.
To set your screen resolution do the following: RIGHT CLICK on the DESKTOP. Select PROPERTIES. CLICK the SETTINGS TAB. MOVE THE SLIDER under SCREEN RESOLUTION until it shows 1024 X768. CLICK OK to apply the resolution.

Schematic Machine Views
Front Frame Rear Frame Tap Views

The Bookmarks panel will allow you to quickly navigate to points of interest.
EC-C2 EC-C3 E-C60 E-C61

Click on any text that is BLUE and underlined. These are hyperlinks that can be used to navigate the schematic and machine views.

EC-C1

VIEW ALL CALLOUTS

When only one callout isshowing on a machine view this button will make all of the callouts visible. This button is located in the top right corner of every machine view page.

HOTKEYS (Keyboard Shortcuts)

FUNCTION
Zoom In Zoom Out Fit to Page Hand Tool Find

KEYS
“CTRL” / “+” “CTRL” / “-” “CTRL” / “0” (zero) “SPACEBAR” (hold down) “CTRL” / “F”

KENR5167-05 November 2010

D7E Track-Type Tractor ElectricalSystem
MDB1-UP SCG1-UP

Volume 1 of 2: Engine & Chassis Volume 2 of 2: Cab
© 2010 Caterpillar, All Rights Reserved

Printed in U.S.A.

COMPONENT TABLE - VOL. 1 OF 2
(ENGINE AND CHASSIS)
Component 12V Battery 1 & 2 Alarm, Backup Block, Junction Coil, Evaporator Compressor, HVAC Control, Coolant Pump Control, Engine Control, Generator Control, HVAC Communications Gateway Control, MotorConverter, Accessory Power Ground, Accessory Power Convertor Ground, Cab ROPS #1 Ground, Cab ROPS #2 Ground, Coolant Pump Ground, Frame #1 Ground, Frame #2 Ground, Frame #3 Ground, Frame (Disconnect Switch) Ground, Frame (Power Invertor) Ground, Front Chassis Ground, Generator Stator Ground, Prelube Motor Ground, Starter Motor Horn, High Horn, Low Invertor, Power Module, Electric Drive Propulson ModuleMotor, Blower Motor, Condenser Motor, Fuel Priming Pump Motor, Precleaner Motor, Prelube Motor, Starter Motor, Washer (LH) Motor, Washer (Rear) Motor, Washer (RH) Motor, Water Jacket Pump Receiver, Electric Mast (LH) Receiver, Electric Mast (RH) Receiver, GPS (LH) Receiver, GPS (RH) Receiver, Laser (LH) Receiver, Laser (RH) Relay, Inlet Air Heater Resistor, CAN 2 Resistor, CAN B Resistor, HVACResistor, Terminating (Coolant Pump Control) Resistor, Terminating (Motor Control) Sender, Fuel Level Sensor, Atmospheric Pressure Sensor, Brake Slope Sensor, Compressor Discharge Sensor, Coolant Temperature Sensor, Coolant Temperature (Separate Circuit) Sensor, Fuel Rail Pressure Schematic Location A-15 I-16 B-16 H-8 J-16 J-2 H-5 F-15 G-8 H-15 B-13 A-13 H-6 H-6 J-1 I-16 A-9 A-10 I-8 E-12 A-7 I-6 B-5I-4 E-3 E-3 G-13 J-10 H-8 G-8 I-2 H-8 B-5 I-4 C-13 C-13 C-13 J-1 G-1 F-1 E-1 D-1 F-1 E-1 G-2 B-3 B-3 H-8 I-2 I-15 D-15 G-2 E-10 H-8 F-2 D-15 G-2 Machine Location 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 Component Sensor, Fuel Temperature Sensor, Generator Speed Sensor #1 Sensor,Generator Speed Sensor #2 Sensor, Hydraulic Pump Pressure Sensor, Hydraulic Temperature Sensor, Inclination Sensor, Intake Manifold Air Temperature Sensor, Intake Manifold Pressure Sensor, Machine ECM Drive Motor Speed #1 Sensor, Motor ECM Drive Motor Speed #1 Sensor, Motor ECM Drive Motor Speed #2 Sensor, Oil Pressure Sensor, Powertrain Lube Sensor, Primary Speed/Timing Sensor, PTO TankTemperature Sensor, Secondary Speed/Timing Sensor, Steering Charge Pressure Sensor, Steering Motor Speed Sensor, Turbo Inlet Air Pressure Solenoid, 3rd Function Valve #1 Solenoid, 3rd Function Valve #2 Solenoid, Blade (Lower) Solenoid, Blade (Raise) Solenoid, Brake Proportional Solenoid, Drum Clutch Release Solenoid, Fan Solenoid, High Pressure Fuel Pump #1 Solenoid, High Pressure Fuel Pump #2 Solenoid,...