Manual Remanufactura Samsung Scx-6122

S AMSUNG SCX-6320
®

TONER & DRUM CARTRIDGE REMANUFACTURING INSTRUCTIONS

SAMSUNG ® SCX-6320 TONER CARTRIDGE

SAMSUNG ® SCX-6320 DRUM CARTRIDGE

www. uninet imaging.com
© 2010 UniNet Imaging Inc. All trademark names and artwork are property of their respective owners. Product brand names mentioned are intended to show compatibility only.
UniNet Imaging does not warrant downloadedinformation. Unauthorized sale, reproduction or distribution of this article is prohibited. For additional support, please contact techsupport@uninetimaging.com

SAMSUNG SCX-6320 TONER & DRUM CARTRIDGE REMANUFACTURING INSTRUCTIONS

REMANUFACTURING THE SAMSUNG
SCX-6320 TONER & DRUM CARTRIDGES
By Mike Josiah and the Technical Staff at UniNet
First released in November 2004, the Samsung SCX-6320Engine is a 22 ppm fax engine that runs at 1200 dpi. The Samsung
toner cartridge SCX-6320D8 is rated for 8,000 pages, and has a list price of $79.00 USD. This engine is similar to the Samsung
SF-830 in that the toner and drum have been split into two different cartridges. These instructions cover both the toner cartridge
and the drum unit. Both cartridges are very simple to remanufacture. Thetoner cartridges are chipped, and the chip does need
to be replaced each cycle. The chip also identifies if it is a Samsung, Xerox (US/Canada), or Xerox (Europe). The SCX-6320
machines have a TONER SAVE function. The toner save mode is basically just like the economode method used by other
manufacturers. Only half the dots are printed using less toner.

CURRENT MACHINES BASED ON THE SCX-6320ENGINE:
Samsung SCX-6120
Samsung SCX-6220
Samsung SCX-6320F
Samsung SCX-6520FN
Xerox WorkCentre M20
Xerox WorkCentre M20i
Xerox CopyCentre C20

PART NUMBERS FOR THE CARTRIDGES:
Samsung Toner
SCX-6320D8/XAA
Samsung Toner
SCX-6320D4
Samsung Drum Unit
SCX-6320R2

8,000 pages
4,000 pages (starter cartridge)
20,000 pages

Xerox Toner Cartridge
Xerox Toner Cartridge
Xerox TonerStarter Cartridge
Xerox Drum Unit

8,000 pages USA/Canada
8,000 pages Europe
4,000 pages
20,000 pages

106R01047
106R01048
113R00671

Samsung and Xerox list pricing as of November 2005 for the toner cartridges is $79.99. The drum units list for $99.99
All list prices shown are in U.S. American dollars. Samsung does not have different part numbers for Europe.

SUPPLIES REQUIRED:
1. 250gdedicated toner for SCX-6320
2. New replacement drum (for drum unit)
3. New replacement wiper blade (for drum unit)
4. Replacement fuse for drum unit (same fuse for use in Samsung SF-5100)
5. Conductive grease (both cartridges)

TOOLS REQUIRED:
1. Phillips head screwdriver
2. Small common screwdriver
3. Spring hook
4. Vacuum approved for toner
Machine and cartridgetroubleshooting/information are covered at the end of this article.
www. uninet imaging.com
© 2010 UniNet Imaging Inc. All trademark names and artwork are property of their respective owners. Product brand names mentioned are intended to show compatibility only.
UniNet Imaging does not warrant downloaded information. Unauthorized sale, reproduction or distribution of this article is prohibited. For additionalsupport, please contact techsupport@uninetimaging.com

SAMSUNG SCX-6320 TONER & DRUM CARTRIDGE REMANUFACTURING INSTRUCTIONS

TONER CARTRIDGE
1. Remove the two screws located on the waste chamber.
Remove the waste chamber. Be careful not to lose the gears!

2. The gears on the waste chamber are on fairly tight so if you are careful there is no need to remove them.
There are locking tabs onthe center shafts that keep the gears in place.
Vacuum/blow out the waste chamber clean.

www. uninet imaging.com
© 2010 UniNet Imaging Inc. All trademark names and artwork are property of their respective owners. Product brand names mentioned are intended to show compatibility only.
UniNet Imaging does not warrant downloaded information. Unauthorized sale, reproduction or distribution of...